Service

Old Fashion Service

Additional Maintenance Requirements

These additional maintenance requirements supplement the Required Maintenance Services, and vary by vehicle.

Aspire	Focus, 2x2, Cougar(2.0L)
Check idle speed every 50,000 km Inspect ignition timing every 100,000 km Replace camshaft drive belt every 100,000 km	Replace cam shaft belt every 200,000km
Contour, Mystique,	Ranger(2.3L & 2.5L), Escape(2.0L)
Replace cam shaft belt every 200,000km	Replace cam shaft belt every 200,000km
Escort, Tracer(1.9L & 2.0L)	Escort, Zx2, Tracer(1.8L)
Replace cam shaft belt every 200,000km	Check idle speed every 50,000km Replace cam shaft belt 100,000km
Probe (2.0L & 2.5L)	T-Bird Super Coupe
Check idle speed every 50,000 km Replace camshaft drive belt every 100,000 km	Check clutch hydraulic fluid level every 50,000 km, if equipped Check supercharger fluid level every 50,000 km
Lincoln LS	Taurus SHO
Change manual transmission fluid every 100,000km	Check battery fluid every 24 months or 40,000 km Replace cam shaft belt and adjust valve clearance every 160,00km
Villager
Change manual transmission fluid every 100,000 km
E & F Series, Expedition, Navigator	Explorer, Ranger
Inspect/adjust 4x2 wheel bearings for end play every 50,000km (If serviceable) Lubricate 4x2 wheel bearings every 100,000km (If serviceable) Replace manual transmission fluid every 100,000km Replace fuel filter every 20,000km Replace climate-control seat filters every 50,000km (Navigator if equipped)	Inspect/adjust 4x2 wheel bearings for end play every 50,000km (If serviceable) Lubricate 4x2 wheel bearings every 100,000km (If serviceable) Replace manual transmission fluid every 100,000km Replace fuel filter every 20,000km Replace climate-control seat filters every 50,000km
Excursion, Explorer Sport Trac	4x4 Vehicles
Inspect/adjust 4x2 wheel bearings for end play every 50,000km (If serviceable) Lubricate 4x2 wheel bearings every 100,000km (If serviceable) Replace manual transmission fluid every 100,000km Replace fuel filter every 20,000km Replace climate-control seat filters every 50,000km	Lubricate transfer case shift pivot bolt and control rod connecting pins every 20,000km Replace transfer case fluid every 100,000km Lubricate front axle RH axle shaft slip yoke every 50,000km (If serviceable) Inspect and lubricate hub locks every 50,000km (If serviceable) Replace Front axle lubricant every 250,000km
Super Duty, F-Super Duty	Diesel Engine
Inspect parking brake fluid level every 20,000km Replace rear axle lubricant every 50,000km (F-450, F-550) Replace manual transmission fluid every 100,000km Replace fuel filter every 20,000km	(Also refer to owner guide supplement) Add FW16 Coolant Conditioner every 12 months or 20,000km Check air filter minder every 5,000km; Replace air filter as required Replace fuel filter every 20,000km
Motorhome/Recreational/Ambulance	Natural Gas Vehicles(NGV)
Replace brake fluid every two years	Drain coalescer and replace fuel filter element and housing O-ring seal every 40,000km Inspect fuel tank every 50,000km at approved Ford gaseous fuel dealers Replace spark plugs 4.6 L NGV (every 100,000km) Replace NGV tanks every 15 years